Product ID:SPEED-E-NAMEL ALL PURPOSE PRIMER, 0317WZ
MSDS Date:03/10/1995
FSC:8010
NIIN:00N072780
MSDS Number: CBYXQ

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ
CARSON, CA 90749
US

Emergency Phone: 303-623-5716

Info Phone: 303-513-0700

Preparer: JOHN R. KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

104 @ 68F.

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 38%

OSHA PEL 1000 PPM

ACGIH TLV: 750 PPM;1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

32 @ 68F.

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 16%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

200 @ 100F.

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

37 @ 100F.

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 10%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

5.1 @ 68F.

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 6%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

73 @ 100F.

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 5%

OSHA PEL 1000 PPM (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

ALUMINUM; (ALUMINUM FLAKE) (SARA 313)

CAS: 7429-90-5

RTECS: BD0330000

OSHA PEL 15 MG/M3 DUST

ACGIH TLV: 10 MG/M3 DUST

PETROLEUM DISTILLATE; (AROMATIC PETROLEUM DISTILLATE BR

CAS: 64742-14-9

OSHA PEL 100 PPM (MFR)

ACGIH TLV: N/K

STODDARD SOLVENT; (ALIPHATIC PETROLEUM DISTILLATE BR

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

INFLAMM, DMG/EVEN DEATH. RPTS HAVE ASSOC RPTD &

RTECS: 9999999ZZ

STUDIES W/RATS HAVE SHOWN THAT PETRO DISTILS CAUSE

RTECS: 9999999ZZ

EVALUATING PETRO WORKERS HAVE NOT SHOWN SIGNIFICANT

RTECS: 9999999ZZ

DETECTABLE AMTS OF CHEM KNOWN TO THE STATE OF

RTECS: 9999999ZZ

IN THIS PROD. INTENTIONAL MISUSE BY DELIB CONC &

RTECS: 9999999ZZ

TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPRO

RTECS: 9999999ZZ

CONCERNING LATEST HAZARD LIST INFO & SAFE HANDLING &

RTECS: 9999999ZZ

BRAZE/WELD DRY COATING W/OUT NIOSH APPRVD

RTECS: 9999999ZZ

CREAMS ARE NOT RECOMMENDED FOR PROTECTION

RTECS: 9999999ZZ

& SHOES IN CASE OF SPILL, SPLASH/EXCESSIVE

RTECS: 9999999ZZ

RETAINED IN THEM.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE NOSE & THROAT IRRIT.
MAY CAUSE NERV SYS DEPRESS CHARACT BY FOLLOWING PROGRESSIVE
STEPS:HDCH, DIZZ, NAUS, STAG GAIT, LASS, LOSS OF COORD, CONFUSN,
UNCON. SKIN/EYE CONT:MAY CAUSE IRRIT/B URNING OF EYES. RPTD/PRLNG
LIQ CONT MAYCAUSE SKIN IRRIT W/DISCOMFORT & DERM. EYE WATERING,
HDCHS, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:NAUS, DIZZ, ETC ARE SIGNS THAT SOLV
LEVELS ARE TOO HIGH. SKIN ABSORPTION:SEE INHAL. ORG SOLVS ARE
EASILY ABSORBED. DRY SKIN, REDNESS/DERM DUE TO DEFAT ACTION OF
SOLVS ARE SIGNS OF EXPOS. INGE ST:SEE INHAL. MAY ALSO RSLT IN GI
DISTRESS. THERE IS DANGER OF PETRO DISTILS ENTERING LUNGS IF
SWALLOWED/VOMITED(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF
MOUTH-TO-MOUTH, CALL MD. EYES:IMMED FLUSH W/PLENTY OF WATER FOR AT
LST 15 MINS; CALL MD. SKIN:WASH W/SOAP & WATER. IF IRRIT OCCURS,
CONT M D. INGEST:CALL MD IMMED, HAVE NAMES OF HAZ INGS READY, DO
NOT INDUCE VOMIT, KEEP HEAD LOWER THAN WAIST. ASPIR OF VOMITUS MAY
RESULT IN CHEMICAL PNEUMONITIS &/OR PULMONARY EDEMA.

Flash Point Method:TCC
Flash Point:-256F,-160C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID CONFINED SPACES. WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUM IN LOW AREAS
OF POOR VENT/TRAVEL ALONG GROUND TO REMOTE IGNIT SITES. CONTENTS
ARE UNDER PRESS. KEEP COOL. EXPOS TO HEAT OR (SUPDAT)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION,
INCLUDING HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING & GEAR.
PREVENT SKIN CONTACT. AVOID BREATHING OF VAPOR. CONFINE IMMEDIATELY
& REMOVE W/INERT ABSORBA NT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECS. KEEP AWAY FROM
HEAT, SPARKS & OPEN FLAME (I.E. ALL IGNIT SOURCES). CAP CNTNR AFTER
EACH USE. DO NOT STORE >120F.
Other Precautions:STORE IN DRY, WELL VENTED PLACE. DO NOT EXPOSE TO
DIRECT SUNLIGHT TO AVOID BURSTING. DO NOT SPRAY NEAR FIRE/FLAME.
AVOID UNNEC CONT. DO NOT TAKE INTERNALLY. DO NOT PUNCTURE CNTNRS.
USE W/ADEQ VENT - D O NOT INHALE. DO NOT SAND, CUT, (ING 18)

Respiratory Protection:DO NOT BREATHE VAPS/MISTS. IF TLV, PEL/OTHER
LIMS ARE EXCEEDED THEN WEAR PROPERLY FITTED NIOSH APPRVD VAP &
PARTICULATE/POS PRESS AIR SUPPLIED RESP FOR USE W/PAINTS DURING
APPLICATION & UNTIL ALL VAPS & MISTS ARE EXHAUSTED. FOLLOW
(SUPDAT)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP CONTAMS
BELOW APPLIC OSHA REQUIREMENTS/OTHER SUGGESTED EXPOS (SUPDAT)
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . APRON, COVERALLS/WORK CLOTHES. PROT (ING 19)
Work Hygienic Practices:WASH THORO AFTER HNDLG & BEFORE EATING/SMOKING.
DO NOT SMOKE/EAT W/OUT FIRST WASHING YOUR HANDS. CHANGE CLOTHES
(ING 20)
Supplemental Safety and Health
EXPLO HAZ:SUNLIGHT MAY CAUSE CANS TO BURST & PROPELL CONTENTS. WATER
FROM FOG NOZZ MAY BE HELPFUL IN COOLING UNRUPTURED CNTNRS TO PVNT
PRESS BUILD-UP. RESP PROT:RESP MFR'S DIRECTIONS FOR PROPER USE. V
ENT:LIMS. USE ONLY EXPLO PROOF EQUIP W/FLAMM MATLS. EYE PROT:& FULL
LGTH FCSHLD. EFTS OF OVEREXP:& CAUSING(ING 11)

Boiling Pt:B.P. Text:>-43F,>-42C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.74 (H*2O=1)
VOC Grams/Liter:5.44
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO
DECOMPOSITION. MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. PLACE IN NON-LEAKING CONTAINERS. DISPOSE OF ABSORBED
MATERIAL I/A/W ALL FEDERAL, STATE & LOCAL REQUIREMENTS. DO NOT
INCINERATE IN CLOSED CONT AINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.